你好,欢迎来到济南济柴环能燃气发电设备湖南快乐十分官方网站!

燃气发电机组的生产离不开哪些技术的开发?

来源:http://zuiai9.com   发布于:2019-07-23

等比例混合气调节技术:

Equivalent mixing control technology:

根据燃气成份和压力,确定合理的空气一燃气混合比,通过节气阀和混合器膜片开度来调整混合气的进气量,实现燃气发动机0―100%负荷全程的等空燃比进气。采用该种结构的混合器,可有效地提高机组的启动性能,机组一次起动成功率可达到100%。加装ATS系统后,可满足应急机组的性能要求。

According to the gas composition and pressure, the reasonable air-gas mixing ratio is determined, and the intake volume of the mixture is adjusted by throttle valve and diaphragm opening of the mixer to realize the equal air-fuel ratio intake of the gas engine at 0-100% load。 The mixer with this structure can effectively improve the start-up performance of the unit, and the success rate of the unit's primary start-up can reach 100%。 After installing ATS system, it can meet the performance requirements of emergency units。

高能量点火技术:

High-energy ignition technology:

点火线圈、传感器、点火模块部件均采用美国最先进的AIJTR0NC公司产品,点火线圈初级电压为160V,次级电压可高达3―4万伏,点火能量大,采用 12v和24v两用点火直流电源供电。火花塞采用日本NGK公司的白金火花塞,白金电极抗氧化能力极强,大大地提高了火花塞的寿命,火花塞寿命可达3000―8000小时。高压线采用闪光式高压线专利产品,机组运行时可产生电光,便于操作人员观察点火系统的运行情况。点火信号盘可方便地调整点火提前角,使发动机运行在最佳状态。以上的配套产品保证了燃气燃烧充分,机组可靠运行,提高了机组运行的可靠性的经济性。

QQ截图20171025151846.jpg

The ignition coil, sensor and ignition module are all made of the most advanced AIJTR0NC products. The primary voltage of the ignition coil is 160V, the secondary voltage can be as high as 3-40,000 volts, and the ignition energy is large. The power supply is 12 V and 24 V dual-purpose ignition DC power supply. The spark plug is made of platinum spark plug made by NGK Company of Japan. The platinum electrode has strong antioxidant ability, which greatly improves the life of spark plug. The life of spark plug can reach 3000-8000 hours. Flash type patented high voltage wire is used for high voltage wire. Electro-optic light can be produced when the unit is running, which is convenient for operators to observe the operation of ignition system. The ignition signal plate can easily adjust the ignition advance angle to make the engine run in the best state. The above matching products ensure the full combustion of gas and the reliable operation of the unit, and improve the reliability and economy of the operation of the unit.

增压中冷技术:

Supercharging intercooling technology:

针对燃气的成份和参数,优化设计和匹配增压器、中冷器,对混合气进气采用增压中冷技术,实现对燃气发动机功率的强化,提高发动机功率,对于进口品牌发动机,在1500r/min时,机组电输出最大升功率不低于15KW/L(发动机排量),对于国产品牌发动机,在1500r/min时,机组电输出最大升功率不低于11 Kw/L(发动机排量)。

Aiming at the components and parameters of gas, the turbocharger and intercooler are optimized and matched。 The turbocharging and intercooling technology is adopted for mixed gas intake to strengthen the power of gas engine and improve the power of engine。 For imported brand engines, the maximum power output of the unit is no less than 15KW/L at 1500r/min。 For domestic brand engines, the maximum power output of the unit is not less than 11 Kw/L (engine displacement) at 1500r/min。

更多的关于燃气发电机组的问题或者详细的内容,请进入我们公司的网站:http://zuiai9.com  网站中会有很多的内容仅供参考。

For more questions or details about gas generating units, please go to our website: http://www。huannengpower。com。 There will be a lot of content for reference only。


上一篇:煤层气(瓦斯)发电机组的可以使用的条件及特点
下一篇:瓦斯发电机组的效率怎么样

河南快3 黑龙江快乐十分 湖北快3 上海11选5 湖北11选5 广东11选5 黑龙江快乐十分 湖南幸运赛车 黑龙江11选5 黑龙江11选5